Sat, Feb 06, 2021
AD 2021-02-20 Prompted By A Report Of A Crack In A Rotating Scissor Fitting
The FAA is adopting a new airworthiness directive (AD) for all Hélicoptères Guimbal Model Cabri G2 helicopters.
This AD was prompted by a report of a crack in a rotating scissor fitting. This AD requires an initial and repetitive inspections of certain rotating and non-rotating scissor fittings, and depending on the results, replacing the affected assembly. This AD also prohibits installing certain main rotor hubs (MRHs) and swashplate guides unless the initial inspection has been accomplished. The FAA is issuing this AD to address the unsafe condition on these products. This AD becomes effective February 22, 2021.
Supplementary Information: The EASA, which is the Technical Agent for the Member States of the European Union, has issued EASA AD No. 2020-0199, dated September 21, 2020, and corrected September 24, 2020 (EASA AD 2020-0199), to correct an unsafe condition for Hélicoptères Guimbal (HG) Model Cabri G2 helicopters. EASA advises of a report of a crack in a rotating scissor fitting discovered during maintenance. According to EASA, the suspected root cause of the crack was corrosion under residual stress. This condition, if not addressed, could result in failure of the rotating or non-rotating scissor fitting on either the MRH or the swashplate guide, and subsequent loss of control of the helicopter.
Accordingly, EASA AD 2020-0199 requires an initial and repetitive inspections of the rotating and non-rotating scissor fittings part number (P/N) G12-00-200 installed on the MRH or swashplate guide, respectively. If a crack is detected, the EASA AD requires replacing the affected MRH or swashplate guide with a serviceable part. The EASA AD prohibits installing certain MRHs and swashplate guides unless the initial inspection has been accomplished. The EASA AD also requires reporting certain information to HG.
More News
Takeoff Roll The process whereby an aircraft is aligned with the runway centerline and the aircraft is moving with the intent to take off. For helicopters, this pertains to the act>[...]
“We’re proud of the hard work that went into receiving this validation, and it will be a welcome relief to our customers in the European Union. We couldn’t be mor>[...]
Also: 1800th E-Jet, Uncle Sam Sues For Landing Gear, Embraer Ag Plane, Textron Parts A friend of the family reported that Lt. Col. (Ret.) Richard Glenn Rutan flew west on Friday, M>[...]
Also: Virgin Galactic, B-29 Doc to Allentown, Erickson Fire-Fighters Bought, FAA Reauthorization After dealing with a big letdown after the unexpected decision by Skyreach to disco>[...]
"Aircraft Spruce is pleased to announce the acquisition of the parts distribution operations of Wag-Aero. Wag-Aero was founded in the 1960’s by Dick and Bobbie Wagner in the >[...]