'Preflight, Preflight, Preflight'
Yikes... if I had a dime for every time I heard my instructors
emphasize the importance of a good preflight (or another dime for
every time I said it to me my students once I became an
Instructor), I could buy the whole nation health care coverage. Yet
another case in point made itself evident last month as the
oh-so-expensive (and critical) rotor system of an AS355 was
compromised when an engine cowling door somehow made contact with
the rotor blades. Take my word for it... while the bill will be
huge, the cost could have been SO MUCH worse.
NTSB Identification: WPR10LA075
Nonscheduled 14 CFR Part 135: Air Taxi & Commuter
Accident occurred Sunday, December 06, 2009 in Temple Bar, AZ
Aircraft: AEROSPATIALE AS 355F1, registration: N548SA
Injuries: 7 Uninjured.
This is preliminary information, subject to change, and may
contain errors. Any errors in this report will be corrected when
the final report has been completed.
On December 6, 2009, about 1030 Pacific standard time, an
Aerospatiale AS 355F1 helicopter, N548SA, was substantially damaged
during cruise flight following the left engine cowling door opening
in flight near Temple Bar, Arizona. The helicopter was registered
to and operated by HeliUSA Airways Inc., Las Vegas, Nevada, under
the provisions of Title 14 Code of Federal Regulations Part 135.
The commercial pilot and six passengers were not injured. Visual
meteorological conditions prevailed and a company flight plan was
filed for the cross-country flight. The air tour flight originated
from the Mc Carran International Airport (LAS), Las Vegas, about
1000, with an intended destination of Grand Canyon, Arizona.
The pilot reported that during cruise flight, he heard a
“thumping” noise followed by slight feedback within the
cyclic control. The pilot contacted a second company helicopter to
have them visually inspect the helicopter in flight. The pilot of
the second helicopter informed the pilot that the left engine
cowling appeared to be open and partially separated. The pilot
initiated a precautionary landing to a dirt road and landed without
further incident.
Examination of the helicopter by a Federal Aviation
Administration (FAA) inspector revealed that two of the three main
rotor blades were damaged. One main rotor blade exhibited a
one-inch long gouge about one-quarter of an inch in depth near the
blade root. A portion of the left engine cowling was separated and
not located.