Mon, Nov 27, 2017
January Accident May Be Related To Problem With Engine Oil Drain System
The FAA has issued a Special Airworthiness Information Bulletin (SAIB) warning of a possible blockage of the engine oil drainage system on Airbus Helicopters Deutschland (Airbus Helicopters) Model MBB-BK 117 C-2 helicopters.
On January 26, 2017 an operator of a BK117 C-2 experienced an in-flight engine fire and made an emergency landing in Sioux Falls, South Dakota. Although still under investigation, the engine fire could be related to engine oil coke chips plugging the return scavenge line for the rear bearing of the gas generator. On September 8, 2017 a BK117 C-2 helicopter was destroyed when it crashed near Hertford, North Carolina. The NTSB preliminary investigation found that the number 2 engine rear turbine shaft bearing exhibited discoloration consistent with overheating and lack of lubrication. Through the course of inspecting the engine issue for scavenge line blockage, a BK117 C-2 operator discovered a separate, airframe-related issue. The operator detected various levels of coking blockage of engine drain lines. Airbus Helicopters prescribes a general visual inspection of the bearing compartment area. There are no prescribed inspections of the drain tube or drain collector to check for blockage. A blocked
drain line may, under certain circumstances, present a risk for an engine fire and/or inflight shutdown of the affected engine.
The FAA recommends the actions below for all owners, operators, and maintainers of Airbus Helicopters BK117 C-2 helicopters. The actions should be performed for each engine at intervals not to exceed 100 hours time-in-service (TIS). Refer to Fig. 01 in Airbus Helicopters AMM 71-71-01, dated March 1, 2016 and to Figure 1 of this SAIB.
Disconnect the rear bearing lines part numbers AE709636-1 (hose), 117-600381.111 (hose), and 117-600381.105 (hose) from the drain collector part number B717M1028801 or 117-602061 (drain collector) and disconnect the drain collector from the engine deck.
Visually check the drain collector and hoses for obstructions. These obstructions may include carbon and coke deposits. Contact Airbus Helicopters for recommended cleaning procedures if there are any obstructions.
If there are no obstructions or after performing the above actions, reconnect the drain collector to the engine deck and reconnect the drain/vent lines to the drain collector per approved maintenance instructions.
(Image provided with FAA SAIB)
More News
Airport Marking Aids Markings used on runway and taxiway surfaces to identify a specific runway, a runway threshold, a centerline, a hold line, etc. A runway should be marked in ac>[...]
"It is extremely difficult, if not impossible, for manned aircraft to see a drone while conducting crop-enhancing and other aerial applications at low altitudes and high speeds. We>[...]
Aero Linx: The Skyhawk Association The Skyhawk Association is a non-profit organization founded by former Skyhawk Pilots which is open to anyone with an affinity for the A-4 Skyhaw>[...]
“The T-54A benefits from an active Beechcraft King Air assembly line in Wichita, Kansas, where all required METS avionics and interior modifications are installed on the line>[...]
Aero Linx: Aerostar Owners Association The Association offers the Aerostar Owner a unique opportunity to tap an invaluable source of information concerning the care and feeding of >[...]