Wed, Feb 02, 2005
Problem: Strength, Durability Of Tip-Up Canopy Attachment
If you have or are building a Van's
RV-7 or RV-9 with the standard tip-up canopy, click on over to the
company's web site and check out Service Bulletin 05-01-01, which
was issued last week.
Van's engineers have strengthened the area of the plane where
the canopy attaches; the Bulletin says, "The 'new configuration'
provides a more direct load path.... Additionally, the new
configuration is simpler to install and slightly lighter."
The bulletin applies equally to the taildragger basic models and
trigear -A model sport planes. Indeed, almost all RV-7s and -9s
with the tip-up canopy are affected; only kits shipped since Dec.
19, 2004 incorporate the new parts. Other RV models,including the
RV-7s ancestor, the RV-6, are not affected. Nor are RV-7 and RV-9
series airplanes or kits with the optional sliding canopy.
If you have a finished aircraft, or
have already riveted together the area in question using the
original parts, Van's will provide a spacer plate and a set of four
screws and washers that serve the same purpose as the new design.
Van's provides this kit, the "7/9 TIP-UP SPACER KIT," free of
charge.
If you have not completed your RV-7 or RV-9 kit to the point of
drilling the attach holes in the F-706A-L/R Bulkhead for the
F-732C-L/R plates, you can use the "new configuration" parts that
are being shipped with the most current RV kits. Van's Aircraft
calls this one the "7/9 TIP-UP NEW CONFIG" kit and it, too, is free
on request to RV-7/-7A/-9/-9A kit owners and builders.
More News
Takeoff Roll The process whereby an aircraft is aligned with the runway centerline and the aircraft is moving with the intent to take off. For helicopters, this pertains to the act>[...]
“We’re proud of the hard work that went into receiving this validation, and it will be a welcome relief to our customers in the European Union. We couldn’t be mor>[...]
"Aircraft Spruce is pleased to announce the acquisition of the parts distribution operations of Wag-Aero. Wag-Aero was founded in the 1960’s by Dick and Bobbie Wagner in the >[...]
IDENT Feature The special feature in the Air Traffic Control Radar Beacon System (ATCRBS) equipment. It is used to immediately distinguish one displayed beacon target from other be>[...]
Aero Linx: Pararescue Air Force Pararescuemen, also known as PJs, are the only DoD elite combat forces specifically organized, trained, equipped, and postured to conduct full spect>[...]