Fri, Jan 14, 2005
AD/THIELERT/1 Amdt 1: Engine Failure Due to Electrical System
Failure
Applicability: All
TAE125-01 aircraft engines.
Requirement: 1. If not previously accomplished
in accordance with the original issue of this Directive modify the
electrical power supply system by accomplishing one of the
following three modifications in accordance with relevant aircraft
manufacturer or supplemental type certificate holder documentation
(Thielert Aircraft Engine GmbH Service Bulletin TM TAE 125-008
Revision 1 also refers):
a. Replace alternator part number (P/N) 02-7150-55002R2 with
alternator P/N 02-7150-55002R3.
b. Replace alternator P/N 02-7150-55002R2 with alternator and
alternator regulator as follows:
(i) For Diamond aircraft installations - Alternator P/N
02-7150-55008R1 with Alternator Regulator ALT REG.
(ii) For all other installations - Alternator P/N 02-7150-55800R1
with Alternator Regulator ALT REG.
c. Install a stabilising capacitor.
2. Check the actual capacity of the aircraft battery
in accordance with Gill Aircraft Battery Service Manual (Gill
Document Number Q01-1120) Chapter 7.7 - continued airworthiness
determination for Gill aircraft batteries.
Note: LBA AD D-2004-457R1 (EASA
approval 2005-244) refers.
Compliance: For Requirement 1 - At
the next 300 hourly inspection, but no later than 30 April
2005.
For Requirement 2 - At each 100 hourly inspection until
Requirement 1 is accomplished.
This Amendment becomes effective on 19 January 2005.
Background: The German Luftfhart-Bundesamt has
advised that during tests of the electrical system conducted by the
engine manufacturer it was found that in case of a failure of the
battery line, of the battery relay or of the battery the engine may
fail. It was established that the reason for this failure was an
electrical malfunction of the alternator.
The actions specified in the original issue of this Directive
were intended to prevent an in-flight engine failure in case of a
failure of the electrical aircraft power supply, which could result
in an emergency landing or loss of power of the aircraft. This
amendment, whilst reflecting the requirements of the original
issue, extends the compliance time and introduces a repetitive
battery capacity check until modifications are accomplished. The
amendment also introduces minor formatting changes The original
issue of this Directive became effective on 23 December 2004.
More News
Aero Linx: International Flying Farmers IFF is a not-for-profit organization started in 1944 by farmers who were also private pilots. We have members all across the United States a>[...]
From 2017 (YouTube Version): Remembrances Of An Israeli Air Force Test Pilot Early in 2016, ANN contributor Maxine Scheer traveled to Israel, where she had the opportunity to sit d>[...]
"We renegotiated what our debt restructuring is on a lot of our debts, mostly with the family. Those debts are going to be converted into equity..." Source: Excerpts from a short v>[...]
Also: B-29 Superfortress Reunion, FAA Wants Controllers, Spirit Airlines Pulls Back, Gogo Galileo Van's Aircraft posted a short video recapping the goings-on around their reorganiz>[...]
Chart Supplement US A flight information publication designed for use with appropriate IFR or VFR charts which contains data on all airports, seaplane bases, and heliports open to >[...]