FAA Issues Lycoming Engine Connecting Rod AD | Aero-News Network
Aero-News Network
RSS icon RSS feed
podcast icon MP3 podcast
Subscribe Aero-News e-mail Newsletter Subscribe

Airborne Unlimited -- Recent Daily Episodes

Episode Date

AMA Drone Report

Airborne-Monday

Airborne-Tuesday

Airborne-Wednesday

Airborne-Thursday

Airborne-Friday

Airborne-Unmanned w/AUVSI

Airborne On ANN

AMA 10.19.17

Airborne 10.16.17

Airborne 10.17.17

Airborne 10.18.17

Airborne 10.19.17

Airborne 10.20.17

Airborne-Unmanned 10.17.17

Airborne-YouTube

AMA 10.19.17

Airborne 10.16.17

Airborne 10.17.17

Airborne 10.18.17

Airborne 10.19.17

Airborne 10.20.17

Airborne-Unmanned 10.17.17

NEW!!! 2017 AirVenture Innovation Preview -- YouTube Presentation / Vimeo Presentation

Sat, Aug 12, 2017

FAA Issues Lycoming Engine Connecting Rod AD

Follows Several Reports Of Failure Of The Part Leading To In-Flight Shutdowns

The FAA has issued an Airworthiness Directive (AD) for the connecting rods in certain models of Lycoming engines, and asked for comments on the AD (2017-16-11).

The AD requires an inspection of connecting rods and replacement of affected connecting rod small end bushings. It was prompted by several reports of connecting rod failures resulting in uncontained engine failure and in-flight shutdowns (IFSDs).

The FAA says it has received 5 reports of uncontained engine failures and IFSDs due to failed connecting rods on various models of Lycoming Engines reciprocating engines listed in Table 1 of Lycoming Engines Mandatory Service Bulletin (MSB) No. 632B, dated August 4, 2017, that were overhauled or repaired using any replacement part listed in Table 2 of Lycoming Engines MSB No. 632B, dated August 4, 2017, which was shipped from Lycoming Engines during the dates listed in Table 2 of Lycoming Engines MSB No. 632B, dated August 4, 2017.

This AD requires accomplishing the instructions in Lycoming Engines MSB No. 632B, dated August 4, 2017, except for the instruction to complete the online survey as specified in the MSB. This condition, if not corrected, could result in uncontained engine failure, total engine power loss, IFSD, and possible loss of the airplane. The purpose of the AD is to prevent connecting rod failure, the agency says.

The FAA says this is an unsafe condition that requires the immediate adoption of this AD. The FAA has found that the risk to the flying public justifies waiving notice and comment prior to adoption of this rule because compliance is required within 10 operating hours. Therefore, we find that notice and opportunity for prior public comment are impracticable and that good cause exists for making this amendment effective in less than 30 days. Comments are invited, however, and must be submitted by September 25, 2017.

The FAA estimates that the AD affects 778 engines installed on airplanes of U.S. registry. The cost of compliance with the inspection aspect of the AD AD, including labor, is estimated to be $1,425 per engine totalling $1,108,650.00 per inspection cycle for all U.S. operators.

If the connecting rods need to be replaced, the FAA estimates that the cost, including labor and parts, would be $2,170 per engine for four cylinders, $6,680 for six cylinders, and $6,850 for eight cylinders.

(Image from file)

FMI: AD

Advertisement

More News

RFP: ANN Seeking New Site/Facility For Major Studio Upgrade

It's Official: Aggressive Upgrades For New Airborne Programs WILL Require New Digs It's been in development for years, but we're getting to a point where we think we can pull off s>[...]

Airborne-Unmanned 10.17.17: Eagles v Drones, DJI AeroScope, Drone Policy

Also: AeroVironment Award, Washington State Patrol, Altavian Nova UAS, Robotaxis The French Military is training four Golden Eagles to attack drones in flight as a way to defend ag>[...]

Airborne 10.19.17: 200th TBM 900-Series, MooneyShares, E-AB Accident Stats

Also: Supersonic Test, Kobe Steel, Sullenberger Awarded, A-29 Super Tucanos, Textron, 109th AW CDR Daher recently rolled out its 200th TBM 900-series very fast turboprop aircraft s>[...]

Airborne 10.19.17: 200th TBM 900-Series, MooneyShares, E-AB Accident Stats

Also: Supersonic Test, Kobe Steel, Sullenberger Awarded, A-29 Super Tucanos, Textron, 109th AW CDR Daher recently rolled out its 200th TBM 900-series very fast turboprop aircraft s>[...]

Airborne 10.18.17: Airbus C Series Deal, Red Bull!, Drone v Airline

Also: Glasair 2 And 3 Sold, Send Solutions, Blue Angels, SSBJ, D8 Airliner, Stage 5 Aircraft, Global Supertanker Airbus SE and Bombardier are to become partners on the C Series air>[...]

blog comments powered by Disqus



Advertisement

Advertisement

Podcasts

Advertisement

© 2007 - 2017 Web Development & Design by Pauli Systems, LC